Volvo Cars has decided that there may be a safety defect affecting a small number of 2025 Volvo EX30 vehicles. The potential issue involved the high-voltage battery. Although there have been no reported incidents, warranty claims, or service reports in the United States, the company is taking precautionary steps to reduce any possible safety risk while a permanent repair is developed.
The concern centers on the vehicle’s high-voltage battery cells. According to Volvo, a manufacturing process deviation may result in the formation of lithium plating growth inside certain battery cells. Over time, this condition can increase the risk of an internal short circuit, which in rare circumstances could cause the battery to overheat.
If such a short circuit were to occur, it could lead to a thermal event, meaning excessive heat and, in extreme cases, the possibility of fire. While this scenario is considered unlikely, Volvo determined the issue warranted a safety recall out of an abundance of caution.
Drivers may receive a warning if a problem develops. In affected vehicles, a battery overheating message would appear in the Driver Information Module, alerting the driver to the condition.
Volvo first became aware of the issue in July 2025, after receiving a report of potential high-voltage battery cell overheating outside the United States. The company launched an internal investigation, which was later escalated to its Critical Concern Action Process. After technical analysis and risk assessment by the Critical Concern Management Team, Volvo concluded that the issue could present an increased risk to motor vehicle safety. On December 26, 2025, the decision was made to issue a safety notification recall.
While the investigation continues, Volvo has issued interim guidance for affected owners. Customers are being advised to limit battery charging to a maximum of 70 percent state of charge and to avoid parking their vehicles indoors or near structures. These recommendations are intended to reduce battery stress and minimize potential risk until a final remedy is available.
Volvo is currently developing a permanent service solution. Future production has already been updated to include a new high-voltage battery variant designed to eliminate the condition. Owner notification letters are expected to be mailed beginning February 23, 2026, at which point dealers will provide further instructions.
This recall is identified by Volvo recall number R10355 and National Highway Traffic Safety Administration campaign number 26V-001.
If you own a 2025 Volvo EX30 and receive a recall notice, following the interim guidance and staying in contact with your dealer is the best course of action while the final repair is completed.
