A possible malfunction of the hood safety system and hood lock system of certain 2006-2014 Subaru Tribeca vehicles, will have approximately 77,000owners returning to their dealerships for repairs. According to reports filed with the NHTSA, rusted parts and/or solidified grease within the springs inside of the hood safety system and/or the hood lock system may result in a latch open condition when the hood is closed. The hood could unexpectedly open while driving, interfering with the driver’s visibility and increasing the risk of an accident. Continue reading

Ford Motor Co. has filed a law suit against automobile parts supplier Dana Holding Corp. over corrosion issues that forced Ford to recall over 425,000 1999-2003 Ford Windstar minivans. The original recall, issued in August 2010, affected rear axles that were susceptible to fractures after years of service in salt states. Continued complaints led to subsequent Windstar minivan investigations and recalls that affected the front lower control arms, rear attaching brackets and body mount attachments.

In a seven page suit filed last Friday Ford stated that they have suffered substantial damages over the minivan issues and are asking the court to enforce a cost sharing agreement between the two companies. When asked about the lawsuit, Dana offered no comment, saying that the company does not discuss pending litigations. Ford and Dana continue to do business together as they work to resolve the issue.

The National Highway Traffic Safety Administration (NHTSA) is upgrading an investigation into complaints of severe corrosion in the rear wheel wells of certain 2004 Ford Freestar and 2004 Mercury Monterey minivans. The anchor plate for the rear seats on these minivans is mounted on the rear wheel well and difficulty latching the seats is being blamed on the corrosion. There have also been complaints of the anchor mounts detaching from the vehicle completely. The upgraded investigation will include 2005-2007 Freestar and Monterey vans bought and registered in both salt belt and non salt belt states. If the investigation should lead to a recall, almost 83,000 vehicles could be affected.

Ford is recalling certain 2001-2002 Escape SUVs for a problem with the brake system, that could lead to a fire. According to the recall report filed with the National Highway Traffic Safety Administration (NHTSA), the master cylinder reservoir cap could leak fluid onto an anti-lock brake system (ABS) wiring harness connector, causing it to corrode. The corroded connector could short, overheat, and eventually start a fire. Dealers will replace the brake master cylinder reservoir cap and the ABS electrical system will be modified. Ford will be notifying customers starting the last week of January, but because of parts delays, instructions will be given to park vehicles outside until parts become available. Owners wanting more information on the problem can contact the Ford Motor Company customer relationship center at 1-866-436-7332.

>The National Highway Traffic Safety Administration (NHTSA) have opened an investigation into 1996-2004 Nissan Pathfinders and 1997-2003 Infiniti QX4 vehicles over corrosion issues. There have been 35 reports of failure of the front suspension with over half of the complaints saying that steering control was affected. If the investigation should lead to a recall, over 400,000 Pathfinders and QX4 vehicles could be recalled.

A recall for corrosion of Ford’s Windstar and a recently expanded recall for the same issues, has lead the National Highway Traffic Safety Administration (NHTSA) to upgrade their investigation into front end corrosion problems with the minivan. The NHTSA is now reviewing almost 350 complaints related to the vans front engine cradle. This sub-frame which carries the engine, trans-axle, steering and some front end suspension components, is reported to suffer cracking because of excessive corrosion. Almost 100% of complaints have come from salt belt states.

Ford spokesman Wes Sherwood said the company is cooperating with the NHTSA investigation and that they are committed to safety and notifying customers of recalls. According to Ford’s Safety director, The failure rate for the minivan is quite low when considering the age of the vehicles and the amount of miles they have accumulated.

A Massachusetts man, Sean Bowman, was killed when the rear axle of his Ford Windstar cracked in half causing the minivan to crash into a building. A week after the accident, the Bowman family received a recall notice saying that his 2001 Windstar’s axle should be inspected for corrosion that could lead to the axle breaking.

The original recall was announced last August and only after the story of Sean Bowman’s death broke, Ford announced that it would be expanding the recall to add another 37,000 vehicles. The initial recall was for vans in certain colder states where corrosion was a factor, but the expanded recall now covers a larger number of states.

According to the National Highway Traffic Safety Administration (NHTSA), 70 percent of recalled vehicles are repaired within the first 18 months. Recalls issued for older vehicles tend to be much lower and remain on the roads without being fixed, which could lead to Ford facing increased legal action over the issue. Ford continues to experience problems with the recall because of a shortage of parts. Some Windstar owners have complained that their minivans have been sitting at dealerships waiting for repairs for up to four months.