Here are the technical service bulletins we have for the 2015 FORD TRANSIT. If you have any questions, do not hesitate to Contact Us:
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20170124
350000 EQUIPMENT
REPLACING THE ORIGINAL EQUIPMENT SYNC/NAVIGATION SYSTEM WITH EITHER AN AFTERMARKET SYNC/NAVIGATION KIT OR MODIFYING ORIGINAL SYNC/NAVIGATION PARTS TO PROVIDE ADDITIONAL FEATURES IS NOT RECOMMENDED NOR SUPPORTED ON ANY FORD, MERCURY OR LINCO
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20170220
060000 ENGINE (PWS)
SOME 2015-2017 TRANSIT VEHICLES MAY HAVE UNIQUE ACCESSORY DRIVE NOISE CHARACTERISTICS. ENGINEERING REVIEW OF WARRANTY RETURNED BELT TENSIONERS HAS NOT IDENTIFIED AN OUT OF SPECIFICATION PART, NOR HAVE ABNORMAL SOUNDS BEEN RECREATED DURING O
This 2015 FORD TRANSIT Technical Service Bulletin affects the 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
20170302
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
2015-2017 TRANSIT VEHICLES EQUIPPED WITH DUAL REAR WHEELS (DRWS) HAVE A HIGH MOUNT REAR MARKER LAMP THAT DOES NOT ILLUMINATE WITH THE STOP LAMPS. THIS LAMP ASSEMBLY MAY APPEAR TO BE A STOP LAMP BUT IS INTENDED TO ILLUMINATE WITH THE PARKING
This 2015 FORD TRANSIT Technical Service Bulletin affects the 221200 SEATS:FRONT ASSEMBLY:RECLINER
20150301
221200 SEATS:FRONT ASSEMBLY:RECLINER
FORD 2015 TRANSIT HIGH ROOF BUS/WAGON : SERVICE INFORMATION REGARDING VEHICLES HEADLINER THEAT DOES NOT STAY SEATED AT THE C AND HALF PILLAR TRIM. *LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20150301
080000 FUEL SYSTEM, DIESEL
FORD 2015 TRANSIT EQUIPPED WITH 3.2L DIESEL ENGINE: SERVICE INFORMATION BULLETIN REGARDING ENGINE CRANKSHAFT TIMING TOOL UPDATE. LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE
20150301
062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE
FORD 2015 TRANSIT 3.2L: BULLETIN INFORMATION INVOLVING ENGINE LIGHT FOR REDUCTANT PUMP AND REDUCTANT LINE HEATER, AND INCONSISTENT WIRE INSULATION. *LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20150301
060000 ENGINE (PWS)
FORD 2015 TRANSIT VEHICLES: BULLETIN INFORMATION INVOLVING DRIVEABILITY CONCERNS SUCH AS CRANK NO START, HARD START OR RUNS ROUGH. *LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20150729
060000 ENGINE (PWS)
FORD 2015 TRANSIT: BULLETIN INFORMATION INVOLVING TRANSIT VEHICLES BUILT BEFORE 3/30/2015 MAY HAVE DRIVING AND/OR CHECK ENGINE ILLUMINATED LIGHT CONCERNS. *LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20161010
060000 ENGINE (PWS)
SOME 2015-2016 F-150, C-MAX, EDGE, MKS, TAURUS, AND FLEX AND 2016 EXPEDITION, EXPLORER, ESCAPE, FUSION, MUSTANG, MKZ, MKX, NAVIGATOR, TRANSIT AND TRANSIT CONNECT VEHICLES EQUIPPED WITH A 2.0L, 2.5L, 3.5L OR 3.7L GASOLINE ENGINE AND BUILT ON
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20161014
060000 ENGINE (PWS)
SOME 2015-2017 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE AND BUILT ON OR BEFORE 12-SEP-2016 MAY EXHIBIT AN ILLUMINATED MIL WITH DTC P040D - EXHAUST GAS RECIRCULATION TEMPERATURE EGRT SENSOR A CIRCUIT HIGH. THIS MAY BE CAUSED BY A
This 2015 FORD TRANSIT Technical Service Bulletin affects the 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
20150701
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
FORD: NO SERVICE ACTION IS RECOMMENDED FOR THIS CONDITION. PLEASE USE AT YOUR DISCRETION. VARIOUS 2010-2015 VEHICLES MAY EXPERIENCE A TURBULENCE NOISE, SIMILAR TO AN HELICOPTER NOISE, AT HIGHWAY SPEEDS WHEN THE REAR DOOR WINDOW(S) OR SUNROO
This 2015 FORD TRANSIT Technical Service Bulletin affects the 151300 SEAT BELTS:FRONT:RETRACTOR
20150801
151300 SEAT BELTS:FRONT:RETRACTOR
FORD: ACTIVATION OF THE BACK LOCKING EFFECT MAY BE CAUSING FRONT SEAT BELT TO BE BLOCKED *CN
This 2015 FORD TRANSIT Technical Service Bulletin affects the 151000 SEAT BELTS:FRONT
20150801
151000 SEAT BELTS:FRONT
FORD: ACTIVATION OF THE BACK LOCKING EFFECT MAY BE CAUSING FRONT SEAT BELT TO BE BLOCKED *CN
This 2015 FORD TRANSIT Technical Service Bulletin affects the 162300 STRUCTURE:BODY:DOOR
20150601
162300 STRUCTURE:BODY:DOOR
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 162200 STRUCTURE:BODY:BUMPERS
20150601
162200 STRUCTURE:BODY:BUMPERS
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 162000 STRUCTURE:BODY
20150601
162000 STRUCTURE:BODY
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 161000 STRUCTURE:FRAME AND MEMBERS
20150601
161000 STRUCTURE:FRAME AND MEMBERS
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 010000 STEERING
20161117
010000 STEERING
SOME 2010-2016 EPAS EQUIPPED VEHICLES MAY EXHIBIT STEERING RELATED NOISES. THE WORKSHOP MANUAL (WSM) DIAGNOSTIC PROCEDURES HAVE BEEN UPDATED IN SECTION 211-02. WHEN DIAGNOSING AND REPAIRING EPAS STEERING NOISES USE THE UPDATED PROCEDURES.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20161011
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
SOME 2015-2017 TRANSIT VEHICLES EQUIPPED WITH A 3.2L PUMA DIESEL ENGINE MAY EXHIBIT AN OVERHEAT CONDITION DUE TO COOLANT LOSS WITHOUT ANY EXTERNAL COOLANT LEAKS. THIS MAY BE DUE TO AN INTERNALLY LEAKING EXHAUST GAS RECIRCULATION (EGR) COOLE
This 2015 FORD TRANSIT Technical Service Bulletin affects the 030000 BRAKES (PWS)
20161017
030000 BRAKES (PWS)
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. IF THE
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20161018
350000 EQUIPMENT
SOME 2015-2017 TRANSIT HIGH ROOF WAGON VEHICLES BUILT ON OR AFTER 2-JUN-2015 MAY HAVE BEEN SHIPPED WITH A HEADLINER PANEL THAT WAS NOT PROPERLY SEATED, CAUSING A GAP AT THE C AND/OR C 1/2 PILLAR(S). IN MOST CASES THE CONDITION CAN BE RESOLV
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353600 EQUIPMENT:AIR CONDITIONER
20160511
353600 EQUIPMENT:AIR CONDITIONER
AIR CONDITIONING (A/C) INOPERATIVE - DIAGNOSTIC TROUBLE CODE (DTC) P0645
This 2015 FORD TRANSIT Technical Service Bulletin affects the 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
20160511
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
AIR CONDITIONING (A/C) INOPERATIVE - DIAGNOSTIC TROUBLE CODE (DTC) P0645
This 2015 FORD TRANSIT Technical Service Bulletin affects the 330000 INTERIOR LIGHTING
20150501
330000 INTERIOR LIGHTING
FORD: WHEN THEY SHOULD BE OFF, SOME VEHICLES, WITH HIGH LED INTERIOR INTENSITY, ARE EXPERIENCING LED CARGO LAMPS, WITH A LOW GLOW AND NEED NOT BE REPLACED. MODEL 2015 TRANSIT. *PE
This 2015 FORD TRANSIT Technical Service Bulletin affects the 151300 SEAT BELTS:FRONT:RETRACTOR
20150501
151300 SEAT BELTS:FRONT:RETRACTOR
FORD: SOME VEHICLES FRONT SEAT BELTS ARE MAKING NOISE AND FAILS TO RETRACT OR EXTEND PROPERLY DUE TO A POSSIBLE MODIFICATION OF VEHICLE AND BULKHEAD PARTITION. MODEL 2015 TRANSIT. *PE
This 2015 FORD TRANSIT Technical Service Bulletin affects the 151000 SEAT BELTS:FRONT
20150501
151000 SEAT BELTS:FRONT
FORD: SOME VEHICLES FRONT SEAT BELTS ARE MAKING NOISE AND FAILS TO RETRACT OR EXTEND PROPERLY DUE TO A POSSIBLE MODIFICATION OF VEHICLE AND BULKHEAD PARTITION. MODEL 2015 TRANSIT. *PE
This 2015 FORD TRANSIT Technical Service Bulletin affects the 030000 BRAKES (PWS)
20161017
030000 BRAKES (PWS)
SOME 2008-2017 FORD/MERCURY/LINCOLN VEHICLES EQUIPPED WITH SYNC MAY GENERATE A VHR THAT IDENTIFIES A CONCERN WITH THE BRAKES AND SUSPENSION CATEGORY INDICATING SERVICE IS REQUIRED DUE TO A BRAKE SYSTEM WARNING LAMP BEING ILLUMINATED. IF THE
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20160715
060000 ENGINE (PWS)
SOME 2015-2016 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE WITH LESS THAN 10,500 KM (6,500 MILES) AND BUILT ON 5/11/2015 AND THROUGH 2/8/2016 MAY EXHIBIT A CRANK NO START CONDITION AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATIO
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20160715
110000 ELECTRICAL SYSTEM
SOME 2015-2016 TRANSIT VEHICLES EQUIPPED WITH A 3.2L DIESEL ENGINE WITH LESS THAN 10,500 KM (6,500 MILES) AND BUILT ON 5/11/2015 AND THROUGH 2/8/2016 MAY EXHIBIT A CRANK NO START CONDITION AND/OR MALFUNCTION INDICATOR LAMP (MIL) ILLUMINATIO
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20160809
060000 ENGINE (PWS)
2015-2017 - F-SUPER DUTY, F-650/750 WITH 6.7L DIESEL AND 2015-2017 TRANSIT - 3.2L DIESEL EQUIPPED VEHICLES USE A SELECTIVE CATALYTIC REDUCTION (SCR) SYSTEM DESIGNED TO REDUCE THE VEHICLES EXHAUST EMISSIONS. THE DIESEL EXHAUST FLUID (DEF) TA
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20151021
060000 ENGINE (PWS)
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
20150801
353500 EQUIPMENT:ELECTRICAL:NAVIGATIONAL SYSTEM(GLOBAL POSITIONING SYSTEM)
2016 TRANSIT: DISABLED NAVIGATION REPEATER INFORMATION FEATURE NOT DISPLAYED IN INSTRUMENT CLUSTER MESSAGE CENTER *CN
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20150801
350000 EQUIPMENT
2015 TRANSIT: VEHICLES EQUIPPED WITH DIESEL MAY SHOW THE MALFUNCTION INDICATOR LIGHT ILLUMINATED WITH DTC P204F PRESENT IN REDUCTANT DOSING CONTROL MODULE *CN
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20170110
060000 ENGINE (PWS)
TO HELP DIFFERENTIATE ENGINE OIL LEAKS FROM OTHER POSSIBLE SOURCES, A NEW WHITE-COLORED FLUORESCENT ENGINE OIL DYE IS AVAILABLE. WORKSHOP MANUAL (WSM), SECTION 303-00 HAS BEEN REVISED TO REFERENCE THE NEW WHITE-COLORED DYE. THE NEW WHITE FL
This 2015 FORD TRANSIT Technical Service Bulletin affects the 199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
20161026
199000 TIRES:PRESSURE MONITORING AND REGULATING SYSTEMS
SETTING THE CORRECT TIRE INFLATION PRESSURE IS AN IMPORTANT STEP IN THE PRE-DELIVERY PROCESS AND DURING ROUTINE MAINTENANCE INTERVALS. RECENT CUSTOMER CLINICS REVEALED THAT MOST EVERY VEHICLE IN THE CLINICS HAD THE TIRE PRESSURES SET INCORR
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20161223
350000 EQUIPMENT
2015-2017 TRANSIT VEHICLES ORDERED WITH A KEYLESS ENTRY KEYPAD WILL HAVE THE FORD ACCESSORY KEYPAD INSTALLED ON THE VEHICLE AND PROGRAMMED AT THE ASSEMBLY PLANT. THE MASTER KEYCODE CARD WILL BE STOWED IN A CARDBOARD BOX LOCATED IN THE VEHIC
This 2015 FORD TRANSIT Technical Service Bulletin affects the 162300 STRUCTURE:BODY:DOOR
20160509
162300 STRUCTURE:BODY:DOOR
SOME 2015-2016 TRANSIT VEHICLES BUILT ON OR BEFORE 2/15/2016 MAY EXHIBIT CONTACT BETWEEN THE FRONT DOOR AND FENDER. THIS MAY BE DUE TO THE FRONT DOOR CHECK ARM ALLOWING THE DOOR TO OPEN FAR ENOUGH TO BEN THE DOOR HINGES AFTER REPEATED FULL
This 2015 FORD TRANSIT Technical Service Bulletin affects the 162200 STRUCTURE:BODY:BUMPERS
20160509
162200 STRUCTURE:BODY:BUMPERS
SOME 2015-2016 TRANSIT VEHICLES BUILT ON OR BEFORE 2/15/2016 MAY EXHIBIT CONTACT BETWEEN THE FRONT DOOR AND FENDER. THIS MAY BE DUE TO THE FRONT DOOR CHECK ARM ALLOWING THE DOOR TO OPEN FAR ENOUGH TO BEN THE DOOR HINGES AFTER REPEATED FULL
This 2015 FORD TRANSIT Technical Service Bulletin affects the 161000 STRUCTURE:FRAME AND MEMBERS
20160509
161000 STRUCTURE:FRAME AND MEMBERS
SOME 2015-2016 TRANSIT VEHICLES BUILT ON OR BEFORE 2/15/2016 MAY EXHIBIT CONTACT BETWEEN THE FRONT DOOR AND FENDER. THIS MAY BE DUE TO THE FRONT DOOR CHECK ARM ALLOWING THE DOOR TO OPEN FAR ENOUGH TO BEN THE DOOR HINGES AFTER REPEATED FULL
This 2015 FORD TRANSIT Technical Service Bulletin affects the 171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH
20160519
171100 LATCHES/LOCKS/LINKAGES:DOORS:LATCH
SOME 2015-2016 TRANSIT VEHICLES BUILT ON 8/1/2015 AND THROUGH 2/1/2016 MAY EXHIBIT A FRONT DOOR THAT DOES NOT OPEN WHEN USING THE OUTSIDE HANDLE AND REQUIRES A SECOND ATTEMPT.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 162300 STRUCTURE:BODY:DOOR
20160519
162300 STRUCTURE:BODY:DOOR
SOME 2015-2016 TRANSIT VEHICLES BUILT ON 8/1/2015 AND THROUGH 2/1/2016 MAY EXHIBIT A FRONT DOOR THAT DOES NOT OPEN WHEN USING THE OUTSIDE HANDLE AND REQUIRES A SECOND ATTEMPT.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 162000 STRUCTURE:BODY
20170206
162000 STRUCTURE:BODY
SOME 2015-2017 TRANSIT VEHICLES MAY EXHIBIT TRIM ISSUES THAT ARE NOT WARRANTABLE BY FORD. TRANSIT VEHICLES ARE EQUIPPED WITH INTERIOR AND EXTERIOR TRIM WHICH ARE NOT PAINTED AND HAVE A GRAINED APPEARANCE. CONCERNS RELATED TO TRIM PAINT PEEL
This 2015 FORD TRANSIT Technical Service Bulletin affects the 117000 DIGITAL INSTRUMENT PANEL
20140701
117000 DIGITAL INSTRUMENT PANEL
FORD: LOW LEVEL INSTRUMENT CLUSTERS FAILS TO DISPLAY TRANSPORT MODE STATUS, WHEN ITS TO PREVENT REMOTE KEYLESS ENTRY (RKE) AND INTERIOR LIGHT(S) FROM FUNCTIONING WHEN IGNITION KEY IS OFF BUT ENGINE RUNNING. MODEL 2015 TRANSIT.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 356000 EQUIPMENT ADAPTIVE
20140701
356000 EQUIPMENT ADAPTIVE
FORD: LOW LEVEL INSTRUMENT CLUSTERS FAILS TO DISPLAY TRANSPORT MODE STATUS, WHEN ITS TO PREVENT REMOTE KEYLESS ENTRY (RKE) AND INTERIOR LIGHT(S) FROM FUNCTIONING WHEN IGNITION KEY IS OFF BUT ENGINE RUNNING. MODEL 2015 TRANSIT.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20150301
060000 ENGINE (PWS)
FORD 2015 TRANSIT: INFORMATION INVOLVING 3.2L DURATORQ-TDCI: VEHICLES EQUIPPED WITH 3.2L DURATORQ ENGINES BUILT ON OR AFTER 3/6/2015 MAY SET LOW PRESSURE FUEL SYSTEM SENSOR CIRCUIT WHEN THE KEY ON ENGINE OFF SELF TEST PERFORMED. *LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 022000 SUSPENSION:REAR
20150301
022000 SUSPENSION:REAR
2015 FORD TRANSIT: BULLETIN INFORMATION INVOLVING TRANSIT VEHICLES EXPERIENCING A REAR CLUNK, SQUEAK, RATTLE NOISE, WHILE TURNING OVER BUMPS. *LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20150511
060000 ENGINE (PWS)
FORD 2015 TRANSIT: BULLETIN INFORMATION INVOLVING CERTAIN TRANSIT VEHICLES BUILT BEFORE 3/30/2015 MAY HAVE VARIOUS DRIVEABILITY AND CHECK ENGINE LAMP CONCERNS WITH TROUBLE CODES STORED IN THE POWER CONTROL MODULE. *LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 356000 EQUIPMENT ADAPTIVE
20150501
356000 EQUIPMENT ADAPTIVE
FORD: SOME VEHICLES MUST BE EQUIPPED WITH PASSIVE ANTI-THEFT SYSTEM (PATS) BEFORE KEYS CAN BE PROGRAMMED OR ADDED. MODEL 2015 TRANSIT. *PE
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
20150810
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
SUMMARY TO BE PROVIDED ON A FUTURE DATE.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 162300 STRUCTURE:BODY:DOOR
20160323
162300 STRUCTURE:BODY:DOOR
BROKEN INTERIOR SLIDING DOOR HANDLE - BUILT ON OR BEFORE 1/4/2016 ISSUE Some 2015-2016 Transit vehicles built on or before 1/4/2016 may experience a broken interior sliding door handle due to the sliding door lower roller assembly. S
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20160610
350000 EQUIPMENT
2015-2016 TRANSIT 3.2L DIESEL - FUEL FILTER SERVICE TIP
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20160610
080000 FUEL SYSTEM, DIESEL
2015-2016 TRANSIT 3.2L DIESEL - FUEL FILTER SERVICE TIP
This 2015 FORD TRANSIT Technical Service Bulletin affects the 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
20160617
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
2013-2016 ESCAPE,2014-2016 FIESTA, TRANSIT CONNECT AND 2013-2015 FUSION VEHICLES EQUIPPED WITH 1.6L GTDI ENGINE - UPDATED WORKSHOP MANUAL (WSM) SECTION 303-03 COOLING SYSTEM
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20160617
350000 EQUIPMENT
2013-2016 ESCAPE,2014-2016 FIESTA, TRANSIT CONNECT AND 2013-2015 FUSION VEHICLES EQUIPPED WITH 1.6L GTDI ENGINE - UPDATED WORKSHOP MANUAL (WSM) SECTION 303-03 COOLING SYSTEM
This 2015 FORD TRANSIT Technical Service Bulletin affects the 071000 FUEL SYSTEM, GASOLINE:STORAGE
20160926
071000 FUEL SYSTEM, GASOLINE:STORAGE
Diesel customers may inquire about a Distance to Empty (DTE) warning message for the DEF system. It may be necessary to add up to 2.5 gallons of DEF for the system to detect a refill event and clear the DTE warning messages, however it is r
This 2015 FORD TRANSIT Technical Service Bulletin affects the 070000 FUEL SYSTEM, GASOLINE
20160926
070000 FUEL SYSTEM, GASOLINE
Diesel customers may inquire about a Distance to Empty (DTE) warning message for the DEF system. It may be necessary to add up to 2.5 gallons of DEF for the system to detect a refill event and clear the DTE warning messages, however it is r
This 2015 FORD TRANSIT Technical Service Bulletin affects the 151300 SEAT BELTS:FRONT:RETRACTOR
20160930
151300 SEAT BELTS:FRONT:RETRACTOR
Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatb
This 2015 FORD TRANSIT Technical Service Bulletin affects the 150000 SEAT BELTS
20160930
150000 SEAT BELTS
Some vehicles may have a concern where the safety belt retractor webbing does not extract from the stowed position or exhibits excessive pressure on the occupant during use. This may be due to a normal condition which happens when the seatb
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20160914
110000 ELECTRICAL SYSTEM
Some 2013-2017 F-Super Duty, 2015-2017 Transit and 2016-2017 F650-F750 vehicles equipped with a diesel engine may exhibit diagnostic trouble code (DTC) P2201 (NOX Sensor Circuit Range/Performance Bank 1 Sensor 1) in the powertrain control m
This 2015 FORD TRANSIT Technical Service Bulletin affects the 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
20160914
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
Some 2013-2017 F-Super Duty, 2015-2017 Transit and 2016-2017 F650-F750 vehicles equipped with a diesel engine may exhibit diagnostic trouble code (DTC) P2201 (NOX Sensor Circuit Range/Performance Bank 1 Sensor 1) in the powertrain control m
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20160921
060000 ENGINE (PWS)
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
20160921
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
20160921
063140 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CATALYTIC CONVERTOR
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20160921
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
20160921
063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
20160921
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
20160921
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE
20160921
062300 ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
20160921
062200 ENGINE AND ENGINE COOLING:COOLING SYSTEM:FAN
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
20160921
062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
20160921
062000 ENGINE AND ENGINE COOLING:COOLING SYSTEM
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO-CHARGER
20160921
061320 ENGINE AND ENGINE COOLING:ENGINE:OTHER FUEL TYPES:TURBO-CHARGER
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
20160921
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO-CHARGER
20160921
061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO-CHARGER
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
20160921
061110 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:BELTS AND ASSOCIATED PULLEYS
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
20160921
061100 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 061000 ENGINE AND ENGINE COOLING:ENGINE
20160921
061000 ENGINE AND ENGINE COOLING:ENGINE
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20160921
060000 ENGINE AND ENGINE COOLING
The Powertrain Control/Emissions Diagnosis (PC/ED) manual has been revised for diagnosing electronic throttle bodies (ETBs). The ETC_ACT and ETC_DSD PIDs should not used to diagnose possible ETB concerns. The IDS has a limited refresh rate
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20170227
060000 ENGINE (PWS)
SOME 2015-2017 TRANSIT VEHICLES BUILT ON OR BEFORE 17-OCT-2016, EQUIPPED WITH A 3.2L ENGINE, AND WITH LOW TIME IN SERVICE (LESS THAN 8,000 KM (5,000 MILES)) MAY EXHIBIT AN OIL LEAK FROM AREAS SUCH AS THE CRANKSHAFT FRONT SEAL, CRANKSHAFT RE
This 2015 FORD TRANSIT Technical Service Bulletin affects the 175200 LATCHES/LOCKS/LINKAGES:TRUNK LID:LOCK
20150331
175200 LATCHES/LOCKS/LINKAGES:TRUNK LID:LOCK
FORD 2015 POLICE INTERCEPTOR SEDAN VEHICLES: CUSTOMER SATISFACTION PROGRAM REGARDING ENABLE POLICE MODE TRUNK RELEASE. THE PROGRAM WILL BE IN EFFECT THROUGH MAY 31, 2016. *LJ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20150810
060000 ENGINE (PWS)
FORD : TRANSIT 2015 VEHICLES WITH 3.2L DURATORQ ENGINES MAY SHOW AN ILLUMINATED MIL REGARDING THE EXHAUST GAS TEMPERATURE *CN
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20150824
350000 EQUIPMENT
FORD: 2015 TRANSIT BUS/WAGON WITH A HIGH ROOF, WILL EXPERIENCE A GAP OR LOOSE HEADLINER BETWEEN 3-5 MM BETWEEN SIDE TRIM PANEL AT C AND/OR C 1/2 PILLARS AND HEADLINER *CN
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20170912
110000 ELECTRICAL SYSTEM
Some 2015-2018 Transits may exhibit a lack of airflow from the front climate control system cabin vents in fresh air mode. This concern can be due to improper installation of the hood vent air duct plug. The correct location for the plug is
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20170918
350000 EQUIPMENT
2015-2018 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20170918
060000 ENGINE (PWS)
Some 2013-2017 F-Super Duty/2015-2017 Transit/2016-2017 F650-750 vehicles equipped with a diesel engine may exhibit DTC P207F and/or P20EE (Reductant Quality Performance) in the powertrain control module (PCM). When repairing DTC P207F or P
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20170918
110000 ELECTRICAL SYSTEM
Some 2013-2017 F-Super Duty/2015-2017 Transit/2016-2017 F650-750 vehicles equipped with a diesel engine may exhibit DTC P207F and/or P20EE (Reductant Quality Performance) in the powertrain control module (PCM). When repairing DTC P207F or P
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20161123
350000 EQUIPMENT
SOME 2015-2017 LOW ROOF TRANSIT VEHICLES BUILT ON OR BEFORE 30-SEP-2016 AND UPFITTED WITH A ROOF RACK MAY EXHIBIT INTERIOR ROOF BOW BRACKET TO SIDE PANEL SEPARATION. DURING REPAIR, IN ADDITION TO RENEWING THE ORIGINAL SPOT WELDS WITH METAL
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20171030
060000 ENGINE (PWS)
Some 2015-2018 Transit vehicles may have unique accessory drive noise characteristics. Engineering review of warranty returned belt tensioners has not identified an out of specification part, nor have abnormal sounds been recreated during o
This 2015 FORD TRANSIT Technical Service Bulletin affects the 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
20171030
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
Some 2017 F-Super Duty/2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). This
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20171030
080000 FUEL SYSTEM, DIESEL
Some 2017 F-Super Duty/2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). This
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20171107
060000 ENGINE (PWS)
When replacing a 2015-2018 Transit 3.2L Duratorq-TDCi engine assembly or block, two new transmission locator dowel pins (W703519 or W718670) must be installed. This information is available in Workshop Manual, Section 303-01C. The parts cat
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20171107
350000 EQUIPMENT
When replacing a 2015-2018 Transit 3.2L Duratorq-TDCi engine assembly or block, two new transmission locator dowel pins (W703519 or W718670) must be installed. This information is available in Workshop Manual, Section 303-01C. The parts cat
This 2015 FORD TRANSIT Technical Service Bulletin affects the 100000 POWER TRAIN
20171107
100000 POWER TRAIN
When replacing a 2015-2018 Transit 3.2L Duratorq-TDCi engine assembly or block, two new transmission locator dowel pins (W703519 or W718670) must be installed. This information is available in Workshop Manual, Section 303-01C. The parts cat
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20171115
060000 ENGINE (PWS)
Some 2015-2017 Transit vehicles equipped with a 3.5L or 3.7l gasoline engine may exhibit an engine overheat condition or poor A/C cooling due to one or more of the 3 cooling fan fuses being open. If any one of the Battery Junction Box (BJB)
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20171115
110000 ELECTRICAL SYSTEM
Some 2015-2017 Transit vehicles equipped with a 3.5L or 3.7l gasoline engine may exhibit an engine overheat condition or poor A/C cooling due to one or more of the 3 cooling fan fuses being open. If any one of the Battery Junction Box (BJB)
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20170202
060000 ENGINE (PWS)
SOME 2015 TRANSIT VEHICLES EQUIPPED WITH A 3.5L OR 3.7L ENGINE MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0627 (FUEL PUMP A CONTROL CIRCUIT/OPEN) STORED IN POWERTRAIN CONTROL MODULE (PCM)
This 2015 FORD TRANSIT Technical Service Bulletin affects the 072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
20170202
072100 FUEL SYSTEM, GASOLINE:DELIVERY:FUEL PUMP
SOME 2015 TRANSIT VEHICLES EQUIPPED WITH A 3.5L OR 3.7L ENGINE MAY EXHIBIT AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P0627 (FUEL PUMP A CONTROL CIRCUIT/OPEN) STORED IN POWERTRAIN CONTROL MODULE (PCM)
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20170215
060000 ENGINE (PWS)
SOME 2015 TRANSIT VEHICLES BUILT ON OR BEFORE 30-MAR-2015 MAY EXHIBIT VARIOUS DRIVABILITY CONCERNS INCLUDING DIFFICULTY STARTING, MISFIRES AND/OR AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P00BD, P124
This 2015 FORD TRANSIT Technical Service Bulletin affects the 113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY
20170215
113000 ELECTRICAL SYSTEM:STARTER ASSEMBLY
SOME 2015 TRANSIT VEHICLES BUILT ON OR BEFORE 30-MAR-2015 MAY EXHIBIT VARIOUS DRIVABILITY CONCERNS INCLUDING DIFFICULTY STARTING, MISFIRES AND/OR AN ILLUMINATED MALFUNCTION INDICATOR LAMP (MIL) WITH DIAGNOSTIC TROUBLE CODE (DTC) P00BD, P124
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20171102
110000 ELECTRICAL SYSTEM
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use
This 2015 FORD TRANSIT Technical Service Bulletin affects the 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
20171102
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
Some vehicles may exhibit a no start condition with an illuminated malfunction indicator lamp (MIL) and a DTC P161A after PCM replacement. This may be due to the parameter reset procedure not being properly completed. To clear this DTC, use
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
20180214
353400 EQUIPMENT:ELECTRICAL:RADIO/TAPE DECK/CD ETC.
2010-2018 various vehicles equipped with SYNC or SYNC 3 may not function when attempting to find or use the Spotify app via AppLink. As of an update released on 1/15/2018 Spotify will no longer be supporting their AppLink integration. No re
This 2015 FORD TRANSIT Technical Service Bulletin affects the 118000 ELECTRICAL SYSTEM: SOFTWARE
20180219
118000 ELECTRICAL SYSTEM: SOFTWARE
Some 2015-2017 Transit vehicles may fail BCM installation programming when attempting to install a new BCM. The Technical Assistance Center and engineering teams are currently working to resolve this concern. If module programming is unsucc
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
20180223
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Some 2017-2018 F-Super Duty/2016-2018 F650-750 with 6.7L diesel engines and 2015-2018 Transit with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C in the powertrain control module (PCM). This may be due to
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353000 EQUIPMENT:ELECTRICAL
20180110
353000 EQUIPMENT:ELECTRICAL
The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts a
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20180110
350000 EQUIPMENT
The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts a
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353600 EQUIPMENT:AIR CONDITIONER
20180111
353600 EQUIPMENT:AIR CONDITIONER
Some 2015-2018 F-150, Mustang and Transit vehicles built on or before 01-Dec-2017 may have a concern of no airflow from the climate control vents. This may be caused by a seized or sticking A/C clutch. This can be repaired by replacing only
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20180117
060000 ENGINE (PWS)
Some 2015-2018 Transit vehicles equipped with a 3.2L Duratorq-TDCi may exhibit an engine oil leak from the rear crankshaft seal. The Workshop Manual (WSM), Section 303-01 has been updated to include the correct location to apply sealant to
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
20180117
063110 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:CRANKCASE (PCV)
Some 2015-2018 Transit vehicles equipped with a 3.2L Duratorq-TDCi may exhibit an engine oil leak from the rear crankshaft seal. The Workshop Manual (WSM), Section 303-01 has been updated to include the correct location to apply sealant to
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
20180126
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Some 2017 F-Super Duty, 2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). Thi
This 2015 FORD TRANSIT Technical Service Bulletin affects the 150000 SEAT BELTS
20180108
150000 SEAT BELTS
Some 2015-2018 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front se
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353000 EQUIPMENT:ELECTRICAL
20180110
353000 EQUIPMENT:ELECTRICAL
2015-2018 Transit vehicles ordered with a keyless entry keypad arrive with the Ford Accessory keypad installed and programmed. Vehicles built prior to late January 2017 will have a cardboard box containing a master keycode card and personal
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353000 EQUIPMENT:ELECTRICAL
20180110
353000 EQUIPMENT:ELECTRICAL
The Accessory (Wireless) Keyless Entry Keypad can only be used with vehicles that are factory built with Remote Keyless Entry (RKE). The master code for the Accessory (Wireless) Keyless Entry Keypad can be retrieved from FMCDealer - Parts a
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353600 EQUIPMENT:AIR CONDITIONER
20180111
353600 EQUIPMENT:AIR CONDITIONER
Some 2015-2018 F-150, Mustang and Transit vehicles built on or before 01-Dec-2017 may have a concern of no airflow from the climate control vents. This may be caused by a seized or sticking A/C clutch. This can be repaired by replacing only
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20180117
060000 ENGINE AND ENGINE COOLING
Some 2015-2018 Transit vehicles equipped with a 3.2L Duratorq-TDCi may exhibit an engine oil leak from the rear crankshaft seal. The Workshop Manual (WSM), Section 303-01 has been updated to include the correct location to apply sealant to
This 2015 FORD TRANSIT Technical Service Bulletin affects the 100000 POWER TRAIN
20180126
100000 POWER TRAIN
Some 2017 F-Super Duty, 2016-2017 F650-750 equipped with 6.7L diesel engines and 2015-2017 Transit equipped with 3.2L diesel engines may exhibit a MIL on with diagnostic trouble code (DTC) P206C stored in powertrain control module(PCM). Thi
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20180301
110000 ELECTRICAL SYSTEM
Some 2015-2017 Transit vehicles may fail to program the BCM following replacement. To repair, follow BCM installation procedures in Workshop Manual (WSM), Section 419-10 using Integrated Diagnostic System (IDS) or Ford J2534 Diagnostic Soft
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES
20180305
353100 EQUIPMENT:ELECTRICAL:ANTI-THEFT DEVICES
The procedure to program keys on 2015-2018 Transit vehicles depends on if the vehicle is equipped with the Passive Anti-Theft System (PATS). Keys for PATS and non-PATS vehicles look the same, there is no visual difference. Vehicles with PAT
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20180305
080000 FUEL SYSTEM, DIESEL
Some 2011-2018 Super Duty and 2015-2018 Transit vehicles equipped with diesel engines may exhibit diagnostic trouble code (DTC) U0100 stored in various modules after running a continuous memory diagnostic trouble code (CMDTC) test or networ
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20180330
350000 EQUIPMENT
Replacing the original equipment SYNC/Navigation system with either an aftermarket SYNC/Navigation kit or modifying original SYNC/Navigation parts to provide additional features is not recommended nor supported on any Ford, Mercury or Linco
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20180417
110000 ELECTRICAL SYSTEM
Some 2015-2017 Transit vehicles may fail to program the BCM following replacement. To repair, follow BCM installation procedures in Workshop Manual (WSM), Section 419-10 using Integrated Diagnostic System (IDS) or Ford J2534 Diagnostic Soft
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20180418
110000 ELECTRICAL SYSTEM
As noted in FSA 17S34, loss of instrument cluster display can result from wiring corrosion and damage to the Trailer Relay Module on affected Transit vehicles. Complete the 17S34 service action as described prior to addressing any other cus
This 2015 FORD TRANSIT Technical Service Bulletin affects the 355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
20180619
355200 EQUIPMENT:OTHER:OWNERS/SERVICE/OTHER MANUAL
Some 2015-2018 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant trapped in the heater core. Follow the Service Pr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20180619
060000 ENGINE AND ENGINE COOLING
Some 2015-2018 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant trapped in the heater core. Follow the Service Pr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 200000 WHEELS
20180815
200000 WHEELS
Some 2015-2018 Transit may exhibit a front wheel bearing type noise or DTCs C0031 and/or C034 in the anti-lock brake system (ABS) module. If the vehicle exhibits a wheel bearing noise and/or DTCs C0031 and/or C0034, remove the front wheel s
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20180629
350000 EQUIPMENT
Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. This noise may be caused by
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20180629
060000 ENGINE AND ENGINE COOLING
Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. This noise may be caused by
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20180622
060000 ENGINE (PWS)
Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. This noise may be caused by
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20180622
350000 EQUIPMENT
Some 2013-2018 F-150, 2015-2018 Transit/Expedition, and 2015-2017 Navigator vehicles equipped with a 3.5L EcoBoost engine with greater than 20,000 miles may exhibit a tick type noise from the cylinder block area. This noise may be caused by
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20181009
060000 ENGINE AND ENGINE COOLING
Some 2015-2018 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant trapped in the heater core. Follow the Service Pr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20181023
060000 ENGINE (PWS)
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, P2195
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20181023
110000 ELECTRICAL SYSTEM
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, P2195
This 2015 FORD TRANSIT Technical Service Bulletin affects the 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
20181023
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, P2195
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20180703
350000 EQUIPMENT
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Vehicles may also exhibit fr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20180703
080000 FUEL SYSTEM, DIESEL
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Vehicles may also exhibit fr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20180703
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Vehicles may also exhibit fr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20180724
110000 ELECTRICAL SYSTEM
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Vehicles may also exhibit fr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20180724
080000 FUEL SYSTEM, DIESEL
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Vehicles may also exhibit fr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20180724
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Some 2015-2018 Transit vehicles equipped with a 3.2L diesel engine may exhibit "Drive To Clean" maintenance messages and/or an illuminated malfunction indicator lamp (MIL) on with DTC P2459, P2463, and/or P246C. Vehicles may also exhibit fr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 151300 SEAT BELTS:FRONT:RETRACTOR
20180108
151300 SEAT BELTS:FRONT:RETRACTOR
Some 2015-2018 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front se
This 2015 FORD TRANSIT Technical Service Bulletin affects the 150000 SEAT BELTS
20180108
150000 SEAT BELTS
Some 2015-2018 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front se
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20180110
350000 EQUIPMENT
2015-2018 Transit vehicles ordered with a keyless entry keypad arrive with the Ford Accessory keypad installed and programmed. Vehicles built prior to late January 2017 will have a cardboard box containing a master keycode card and personal
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353600 EQUIPMENT:AIR CONDITIONER
20180706
353600 EQUIPMENT:AIR CONDITIONER
Some 2015-2018 Transit vehicles equipped with the Auxiliary Heater / A/C Prep Package 62C are built specifically for A/C system modification. This can be identified on the Professional Technician Society (PTS) website by using vehicle ident
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20180720
350000 EQUIPMENT
Replacement engines may have a fuel injection pump sprocket that does not include a keyway slot. It is acceptable to utilize the original fuel injection pump if it has a keyway slot. Timing the injection pump is not necessary. Refer to Work
This 2015 FORD TRANSIT Technical Service Bulletin affects the 093000 FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM
20180720
093000 FUEL SYSTEM, OTHER:FUEL INJECTION SYSTEM
Replacement engines may have a fuel injection pump sprocket that does not include a keyway slot. It is acceptable to utilize the original fuel injection pump if it has a keyway slot. Timing the injection pump is not necessary. Refer to Work
This 2015 FORD TRANSIT Technical Service Bulletin affects the 073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
20180720
073000 FUEL SYSTEM, GASOLINE:FUEL INJECTION SYSTEM
Replacement engines may have a fuel injection pump sprocket that does not include a keyway slot. It is acceptable to utilize the original fuel injection pump if it has a keyway slot. Timing the injection pump is not necessary. Refer to Work
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20170718
060000 ENGINE (PWS)
Some 2013-2016 F-Super Duty/2015-2017 Transit/2016-2017 F650-750 vehicles equipped with a diesel engine may exhibit DTC P207F and/or P20EE (Reductant Quality Performance) in the powertrain control module (PCM). When repairing DTC P207F or P
This 2015 FORD TRANSIT Technical Service Bulletin affects the 220000 SEATS
20170724
220000 SEATS
Some 2015-2017 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front se
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20190222
110000 ELECTRICAL SYSTEM
Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool ma
This 2015 FORD TRANSIT Technical Service Bulletin affects the 036500 SERVICE BRAKES, HYDRAULIC:ANTILOCK:WHEEL SPEED SENSOR
20190204
036500 SERVICE BRAKES, HYDRAULIC:ANTILOCK:WHEEL SPEED SENSOR
Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. If the vehicle exhibits a wheel bearing noise and/or DTCs C0031 and/or C0034, remove the fro
This 2015 FORD TRANSIT Technical Service Bulletin affects the 021600 SUSPENSION:FRONT:WHEEL BEARING
20190204
021600 SUSPENSION:FRONT:WHEEL BEARING
Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. If the vehicle exhibits a wheel bearing noise and/or DTCs C0031 and/or C0034, remove the fro
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20190307
350000 EQUIPMENT
Some 2015-2019 Transit High Roof Bus/Passenger Wagon vehicles may have a headliner that does not stay seated at the C and/or C and half pillar hard trim. A permanent repair solution for the existing headliners has been developed and is expe
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20190222
110000 ELECTRICAL SYSTEM
Some 2015-2017 vehicles may experience a no crank concern due to a security access key table error. When attempting to program keys or perform a parameter reset, the procedure may fail and the Integrated Diagnostic System (IDS) scan tool ma
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20181122
110000 ELECTRICAL SYSTEM
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 070000 FUEL SYSTEM, GASOLINE
20181122
070000 FUEL SYSTEM, GASOLINE
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20190214
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Certain 2015-2016 Model Year Transit Vehicles Equipped With 3.2L Diesel Engine - Exhaust Gas Recirculation Temperature Sensor Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20190222
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Certain 2015-2017 Model Year Transit Vehicles with a 3.2L Diesel Engine - EGR Cooler Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
20181101
063200 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:MANIFOLD/HEADER/MUFFLER/TAIL PIPE
Some 2011-2019 F-Super Duty, 2015-2019 Transit, 2016-2019 F-650/F-750 and 2018 F-150 vehicles equipped with a 6.7L, 3.2L or 3.0L engine may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P207F, P20EE, P229F, P2201 and/or P2
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20181101
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Some 2011-2019 F-Super Duty, 2015-2019 Transit, 2016-2019 F-650/F-750 and 2018 F-150 vehicles equipped with a 6.7L, 3.2L or 3.0L engine may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P207F, P20EE, P229F, P2201 and/or P2
This 2015 FORD TRANSIT Technical Service Bulletin affects the 010000 STEERING
20190115
010000 STEERING
Some 2015-2019 Transit vehicles may exhibit a power steering fluid leak at the steering pump or gear. This may be due to a cut or damaged O-ring on the power steering line connection. To repair, refer to parts catalog call out 3334 for serv
This 2015 FORD TRANSIT Technical Service Bulletin affects the 151300 SEAT BELTS:FRONT:RETRACTOR
20181219
151300 SEAT BELTS:FRONT:RETRACTOR
Some 2015-2019 Transit vehicles may exhibit front seat safety belts that do not extend or retract properly or may exhibit an abnormal noise. Verify if the vehicle has been modified, in particular if a bulkhead partition between the front se
This 2015 FORD TRANSIT Technical Service Bulletin affects the 350000 EQUIPMENT
20190117
350000 EQUIPMENT
Some 2012-2019 Vehicles may require repairs to the Smartlink system. Smartlink is a Ford Licensed Accessory which has a warranty provided by the accessory manufacturer. Warranty replacement parts for Smartlink that are ordered through Ford
This 2015 FORD TRANSIT Technical Service Bulletin affects the 200000 WHEELS
20190204
200000 WHEELS
Some 2015-2019 Transit vehicles may exhibit a front wheel bearing type noise or DTCs C0031 and/or C0034 in the anti-lock brake system (ABS) module. If the vehicle exhibits a wheel bearing noise and/or DTCs C0031 and/or C0034, remove the fro
This 2015 FORD TRANSIT Technical Service Bulletin affects the 160000 STRUCTURE
20190318
160000 STRUCTURE
When removing and installing a 2015-2019 Transit front subframe, the cage nuts located in the body of the vehicle may become damaged. If the nut spins in its cage when removing or installing the attachment bolts, the nut can be held with a
This 2015 FORD TRANSIT Technical Service Bulletin affects the 020000 SUSPENSION
20190318
020000 SUSPENSION
When removing and installing a 2015-2019 Transit front subframe, the cage nuts located in the body of the vehicle may become damaged. If the nut spins in its cage when removing or installing the attachment bolts, the nut can be held with a
This 2015 FORD TRANSIT Technical Service Bulletin affects the 061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO-CHARGER
20181114
061120 ENGINE AND ENGINE COOLING:ENGINE:GASOLINE:TURBO-CHARGER
For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing and/or replacing turbo related concerns, all steps within the Workshop Manual (WSM) procedure must be followed including replacement of all mandatory discarded parts
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20181119
110000 ELECTRICAL SYSTEM
For 2015-2019 Transit vehicles, multiple fuse assemblies for the high current battery junction box are available for service. Do not replace the high current battery junction box assembly/wire harness to service an open fuse. Use part numbe
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20190325
060000 ENGINE (PWS)
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, P2195
This 2015 FORD TRANSIT Technical Service Bulletin affects the 100000 POWER TRAIN
20190325
100000 POWER TRAIN
Some 2015-2018 Transit vehicles built on or before 24-Jul-2018 may exhibit various drivability concerns including difficulty starting, misfires and/or an illuminated MIL with diagnostic trouble codes (DTCs) P00BD, P1247, P1548, P061B, P2195
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
20190313
063000 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM
Certain 2015-2016 Model Year Transit Vehicles Equipped With 3.2L Diesel Engine - Exhaust Gas Recirculation Temperature Sensor Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20190313
060000 ENGINE AND ENGINE COOLING
Certain 2015-2016 Model Year Transit Vehicles Equipped With 3.2L Diesel Engine - Exhaust Gas Recirculation Temperature Sensor Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20181214
080000 FUEL SYSTEM, DIESEL
Some 2017-2019 F-Super Duty and 2016-2019 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2019 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
20181214
063100 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL
Some 2017-2019 F-Super Duty and 2016-2019 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2019 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic
This 2015 FORD TRANSIT Technical Service Bulletin affects the 061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
20181214
061200 ENGINE AND ENGINE COOLING:ENGINE:DIESEL
Some 2017-2019 F-Super Duty and 2016-2019 F650-750 with 6.7L diesel engines, 2015-2019 Transit with 3.2L diesel engines and 2018-2019 F-150 with 3.0L diesel engines may exhibit an illuminated malfunction indicator lamp (MIL) with diagnostic
This 2015 FORD TRANSIT Technical Service Bulletin affects the 105300 POWER TRAIN:DRIVELINE:DRIVESHAFT
20181102
105300 POWER TRAIN:DRIVELINE:DRIVESHAFT
Technical Service Bulletin informing customers of XL Hybrid 130" wheel base Ford Transit vehicles that the front drive shaft of vehicles should be lubricated immediately with grease and then every 6,000 miles subsequently.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20180919
060000 ENGINE AND ENGINE COOLING
Some 2015-2019 Transit vehicles may have unique accessory drive noise characteristics. Engineering review of warranty returned belt tensioners has not identified an out of specification part, nor have abnormal sounds been recreated during o
This 2015 FORD TRANSIT Technical Service Bulletin affects the 120000 EXTERIOR LIGHTING
20180924
120000 EXTERIOR LIGHTING
2015-2019 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20190129
080000 FUEL SYSTEM, DIESEL
Certain 2015-2017 Model Year Transit Vehicles with a 3.2L Diesel Engine - EGR Cooler Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20190129
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Certain 2015-2017 Model Year Transit Vehicles with a 3.2L Diesel Engine - EGR Cooler Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20190304
060000 ENGINE (PWS)
Some 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may exhibit Drive To Clean maintenance messages and/or an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2459, P2463, and/or P246C. Vehic
This 2015 FORD TRANSIT Technical Service Bulletin affects the 100000 POWER TRAIN
20190304
100000 POWER TRAIN
Some 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may exhibit Drive To Clean maintenance messages and/or an illuminated malfunction indicator lamp (MIL) with diagnostic trouble codes (DTCs) P2459, P2463, and/or P246C. Vehic
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20190214
060000 ENGINE AND ENGINE COOLING
Certain 2015-2016 Model Year Transit Vehicles Equipped With 3.2L Diesel Engine - Exhaust Gas Recirculation Temperature Sensor Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20190222
080000 FUEL SYSTEM, DIESEL
Certain 2015-2017 Model Year Transit Vehicles with a 3.2L Diesel Engine - EGR Cooler Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
20190222
063130 ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL:GAS RECIRCULATION VALVE (EGR VALVE)
Certain 2015-2017 Model Year Transit Vehicles with a 3.2L Diesel Engine - EGR Cooler Replacement
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20190211
110000 ELECTRICAL SYSTEM
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
20190211
103100 POWER TRAIN:AUTOMATIC TRANSMISSION:CONTROL MODULE (TCM, PCM)
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20190426
060000 ENGINE (PWS)
SSM 47948 - 2010-2019 Various Vehicles - Turbocharged Engines - Oil Supply Filter Replacement When Replacing The Turbocharger Or The Turbocharger Oil Supply Tube For 2010-2019 vehicles equipped with turbocharged engines, when diagnosing an
This 2015 FORD TRANSIT Technical Service Bulletin affects the 120000 EXTERIOR LIGHTING
20190523
120000 EXTERIOR LIGHTING
2015-2019 Transit vehicles equipped with dual rear wheels (DRWs) have a high mount rear marker lamp that does not illuminate with the stop lamps. This lamp assembly may appear to be a stop lamp but is intended to illuminate with the parking
This 2015 FORD TRANSIT Technical Service Bulletin affects the 100000 POWER TRAIN
20190510
100000 POWER TRAIN
On vehicles equipped with an automatic transmission it is imperative that the converter pilot hub be greased with Motorcraft Multi-Purpose Grease Spray XL-5-A even if grease was not applied from the factory. Also verify that the engine/tran
This 2015 FORD TRANSIT Technical Service Bulletin affects the 105300 POWER TRAIN:DRIVELINE:DRIVESHAFT
20190524
105300 POWER TRAIN:DRIVELINE:DRIVESHAFT
If a 2015-2017 Transit vehicle originally equipped with a rubber flexible coupling requires replacement of the driveshaft assembly and/or transmission output flange, refer to the parts catalog supersession information for a complete list of
This 2015 FORD TRANSIT Technical Service Bulletin affects the 100000 POWER TRAIN
20190524
100000 POWER TRAIN
If a 2015-2017 Transit vehicle originally equipped with a rubber flexible coupling requires replacement of the driveshaft assembly and/or transmission output flange, refer to the parts catalog supersession information for a complete list of
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353600 EQUIPMENT:AIR CONDITIONER
20190426
353600 EQUIPMENT:AIR CONDITIONER
Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the pr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20190426
110000 ELECTRICAL SYSTEM
Some 2013-2019 vehicles equipped with a EVDC air conditioning (A/C) compressor may exhibit poor A/C performance/improper climate function and/or a diagnostic trouble code (DTC) P06A0 in the powertrain control module (PCM). To support the pr
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE (PWS)
20190211
060000 ENGINE (PWS)
Some 2015 Transit vehicles equipped with a 3.2L engine may exhibit an illuminated MIL with DTCs P24A0 and/or P26A0 stored in the powertrain control module (PCM). Follow the Service Procedure steps to correct the condition.
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353600 EQUIPMENT:AIR CONDITIONER
20190620
353600 EQUIPMENT:AIR CONDITIONER
Some 2015-2019 Transit vehicles may exhibit poor air conditioning (A/C) performance. If the cause of this is found to be a refrigerant leak from the evaporator, it is recommended to replace only the evaporator case as opposed to the entire
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20190401
060000 ENGINE AND ENGINE COOLING
Some 2015-2019 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant becoming trapped in the heater core. To correct t
This 2015 FORD TRANSIT Technical Service Bulletin affects the 160000 STRUCTURE
20190417
160000 STRUCTURE
Some 2015-2019 Transit High-Roof Bus/Passenger Wagon vehicles may experience a loose or unseated headliner at the C and/or C 1/2 pillar(s) causing visible gaps. This may be due to a lack of retention capability of the headliner locator tabs
This 2015 FORD TRANSIT Technical Service Bulletin affects the 133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
20190603
133000 VISIBILITY:POWER WINDOW DEVICES AND CONTROLS
Some 2015-2019 Transit vehicles may exhibit inoperative power door locks and/or power windows due to water intrusion in the door to body harness connector C339 (left) or C340 (right). If corrosion is found, service pigtails JU2Z-14S411-RA (
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20190603
110000 ELECTRICAL SYSTEM
Some 2015-2019 Transit vehicles may exhibit inoperative power door locks and/or power windows due to water intrusion in the door to body harness connector C339 (left) or C340 (right). If corrosion is found, service pigtails JU2Z-14S411-RA (
This 2015 FORD TRANSIT Technical Service Bulletin affects the 100000 POWER TRAIN
20190607
100000 POWER TRAIN
Some 2015-2019 Transit vehicles may exhibit a concern where there is no 4th, 5th, or 6th gear engagement and MIL with DTC P07AA. If diagnostics lead to teardown, make sure to inspect the intermediate shafts mating splines in the rear planet
This 2015 FORD TRANSIT Technical Service Bulletin affects the 980000 UNKNOWN OR OTHER
20200309
980000 UNKNOWN OR OTHER
SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is active
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20200309
110000 ELECTRICAL SYSTEM
SSM 48619 - Various Vehicles - Perimeter Alarm Armed And Original Vehicle Keys Cannot Be Accessed to Enter Vehicle - CAN Protection Strategy Some 2013-2016 Model Year Vehicles may exhibit a concern in which the Perimeter Alarm is active
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20200212
060000 ENGINE AND ENGINE COOLING
SSM 48543 - 2015-2019 Transit - 3.2L Diesel - Overheat Due To Coolant Loss Without An External Coolant Leak Some 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may exhibit an overheat condition due to coolant loss without an
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20200214
060000 ENGINE AND ENGINE COOLING
This program extends the warranty coverage of the reductant heater and sender assembly to 11 years of service or 120,000 miles from the warranty start date of the vehicle, whichever occurs first. This program DOES NOT apply to vehicles th
This 2015 FORD TRANSIT Technical Service Bulletin affects the 353600 EQUIPMENT:AIR CONDITIONER
20191220
353600 EQUIPMENT:AIR CONDITIONER
Some 2015-2019 Transit vehicles may exhibit poor air conditioning (A/C) performance. If the cause of this is found to be a refrigerant leak from the evaporator, this may be due to build up of contaminates inside the evaporator housing. To c
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20200311
060000 ENGINE AND ENGINE COOLING
Some 2015-2019 Transit vehicles equipped with a 3.2L engine, 2018-2019 F150 vehicles equipped with a 3.0L engine, 2017-2019 Super Duty vehicles equipped with a 6.7L engine built on or after 13-May-2017 may exhibit an illuminated malfunction
This 2015 FORD TRANSIT Technical Service Bulletin affects the 060000 ENGINE AND ENGINE COOLING
20200302
060000 ENGINE AND ENGINE COOLING
Some 2015-2019 Transit vehicles equipped with a 3.5L or 3.7L engine may exhibit a lack of heat or uneven heat from side to side. This condition may be due to deposits from the engine coolant becoming trapped in the heater core. To correct t
This 2015 FORD TRANSIT Technical Service Bulletin affects the 330000 INTERIOR LIGHTING
20200210
330000 INTERIOR LIGHTING
SSM 48531 - 2015 Transit - Interior High Intensity LED Cargo Lamps May Emit A Low Glow When Off - Built On Or Before 22-Apr-2015 Some 2015 Transit vehicles built on or before 22-Apr-2015 and equipped with light emitting diode (LED) cargo l
This 2015 FORD TRANSIT Technical Service Bulletin affects the 110000 ELECTRICAL SYSTEM
20200210
110000 ELECTRICAL SYSTEM
SSM 48531 - 2015 Transit - Interior High Intensity LED Cargo Lamps May Emit A Low Glow When Off - Built On Or Before 22-Apr-2015 Some 2015 Transit vehicles built on or before 22-Apr-2015 and equipped with light emitting diode (LED) cargo l
This 2015 FORD TRANSIT Technical Service Bulletin affects the 080000 FUEL SYSTEM, DIESEL
20200302
080000 FUEL SYSTEM, DIESEL
SSM 48601 - 2015-2019 Transit - 3.2L Diesel - Loss Of Power During Driving Under Extreme Cold Weather Conditions Some 2015-2019 Transit vehicles equipped with a 3.2L diesel engine may exhibit a concern about loss of power during driving
This 2015 FORD TRANSIT Technical Service Bulletin affects the 100000 POWER TRAIN
20191220
100000 POWER TRAIN
Some 2015-2020 Ford and Lincoln vehicles may exhibit an illuminated MIL with diagnostic trouble codes (DTCs) P0011, P0012, P0014, P0015, P0016, P0017, P0018, P0019, P0021, P0022, P0024 and/or P0025. This may be due to small debris causing t
This 2015 FORD TRANSIT Technical Service Bulletin affects the 062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
20200507
062100 ENGINE AND ENGINE COOLING:COOLING SYSTEM:RADIATOR ASSEMBLY
Some 2015-2019 Transit vehicles built on or before 31-Dec-2018 and some 2017-2018 E-450 vehicles equipped with a 6.8L engine built on or before 16-Jul-2018 using the Motorcraft Orange coolant may exhibit an engine overheat concern. This con