GM has announced that they will be recalling over 40,000 vehicles sold in warm weather states because these vehicles have plastic parts connected to the fuel pump which could crack and leak. Fuel leakage in the presence of an ignition source could result in a fire.

GM says there have been no reports of fires or injuries related to the defect. The company began investigating the issue in 2011 after a dealer reported fuel leaks from some vehicles. Warranty data indicates that the problem is more common in vehicles registered in warm weather states. The vehicles affected by this problem include:

Owners wanting more information about the problem can contact General Motors at 1-800-521-7300.

Ford is asking owners of certain 2013 Escape vehicles equipped with 1.6L engines and manufactured between October 2011 to July 2012, to not drive their vehicles until a fuel line in the engine compartment has been replaced. The fuel lines could split and leak, causing an engine compartment fire. Owners can contact their local Ford or Lincoln dealer to arrange to have their vehicle picked up for repairs and will provide a rental vehicle if needed. For more information about the problem, owners can contact Ford at 1-866-436-7332.

Volkswagen has announced a recall involving certain 2012 Passat vehicles built between January 2011 through to June 2011. According to the recall report submitted to the National Highway Traffic Safety Administration (NHTSA), certain vehicles may have been built with a diesel fuel filter element that does not seal correctly. A fuel leak in the presence of an ignition source could lead to an engine fire. Owner will be notified of the problem starting in May, and dealers will replace the element with a serviceable one. Owners wanting more information about the problem can contact Volkswagen at 1-800-822-8987.

Volvo has announced a recall for certain 2012 S60 and 2012 XC60 vehicles because an an incorrect mixture and over application of under body coating could result in ridged, icicle like extrusions hanging from the vehicles undercarriage. These extrusions could penetrate the fuel line causing leaks that could increase the risk of fire. Dealers will inspect the vehicle undercarriage and remove any excessive under body coating in the fuel line area. I the inspection reveals that the fuel lines have been damaged, they will replace them free of charge. Owners wanting more information about the problem can contact the Volvo customer care center at 1-800-458-1552.

Nissan is recalling certain Nissan and Infiniti vehicles for a fuel pressure sensor that may not have been tightened to the correct manufacturers specifications. The sensor may loosen as a result of heat and vibration, causing fuel to leak and increasing the risk of fire. Nissan will inspect and replace the the fuel pressure sensor as necessary. Owners can contact Nissan customer service at 615-725-1000 for more information. The vehicles involved in this recall include:

The National Highway Traffic Safety Administration (NHTSA) is investigating certain 2003-2006 Mercedes Benz E55 AMG sedans and wagons for potential gas leaks. The NHTSA has received over 20 reports from owners who complained about the smell of gasoline inside and outside the vehicle. In some cases, a visible fuel leak was noticed from the fuel sending unit at the top of the fuel tank, underneath the cushion in the rear seat. Several reports suggest the leakage may be related to a March, 2008 emissions recall conducted by Mercedes Benz (Emissions Recall Campaign # 2008-020001) which involved potential cracking of the fuel filter module in vehicles exposed to high ambient temperatures. If the investigation leads to a recall, over 8,000 vehicles could be affected.

Honda has announced that they will be offering extended warranty on some 2006-2011 Honda Civic Hybrid vehicles, due to small cracks that could develop in the gas tanks. According to Honda, the cracks are not a safety problem because the potential fuel leak is very small, and comes from the top area of the tank, by the fuel filler, where there is no ignition source nearby. The driver may smell gas vapors and in rare instances may see a small amount of fuel spilled on the ground. The problem is more likely to occur in states known for very hot weather.

In order to promote consumer confidence, the automaker sent a letter to owners informing them of the extended warranty of 10 years or 120,000 miles from the time the vehicle was new. Honda has also reported the problem to the National Highway Traffic Safety Administration (NHTSA), where it is being reviewed.